2008-2009 BRP Sea-Doo 130 hp, 155 hp, 215 hp, 255 hp GTI, GTI Rental, GTI SE, GTX, GTX Limited, Wake, Wake Pro, RXP, RXP-X, RXP-X RS, RXT, RXT-X, RXT-X RS shop manual

Product Information

Table of Contents

Safety Notice

Introduction

• General Information
• Vehicle Information
• Working on Watercraft
• Engine Emissions Information
• Tightening Torque
• Self-Locking Fasteners Procedure
• Loctite Application Procedure
• Manual Information

01. Maintenance

• 1. Maintenance Chart
• 2. Preseason Preparation
• 3. Storage Procedure
     • Procedures
       • Propulsion System
       • Fuel System
       • Engine
       • Electrical System
       • Vehicle
• 4. Special Procedures
     • Towing the Watercraft in Water
     • Submerged Watercraft
     • Water-Flooded Engine
     • Capsized Watercraft

02. Troubleshooting

• 1. Technical Guidelines
     • Engine
     • Electrical System
     • Propulsion
     • Steering System
• 2. Diagnostic Flow Chart
     • Fuel System

03. Engine

• 1. Engine Removal/Installation
     • General
     • Procedures
       • Engine
• 2. Air Intake System
     • General
     • Procedures
       • Air Intake Silencer
• 3. Intake Manifold/Intercooler
     • General
     • Procedures
       • Intake Manifold
       • Intercooler
• 4. Intercooler (255 Engine)
     • General
     • Maintenance
     • Procedures
       • Intercooler Support
• 5. Supercharger
     • General
     • Inspection
       • Supercharger Inlet Cleanliness
       • Supercharger Clutch Slipping Moment (On Engine)
       • Supercharger Clutch Slipping Moment (Bench Test)
     • Procedures
       • Supercharger
• 6. Exhaust System
     • General
     • System Description
     • Maintenance
       • Exhaust System Flushing
     • Procedures
       • Muffler
       • Exhaust Pipe
       • Exhaust Manifold
       • Resonator
       • Exhaust Outlet
       • Exhaust Gas Temperature Sensor (EGTS)
• 7. PTO Housing/Magneto
     • General
     • Procedures
       • PTO Housing
       • PTO Seal
       • PTO Coupling
       • Starter Drive Bearing
       • Stator
       • Rotor and Trigger Wheel
       • Ring Gear
       • Starter Drive
• 8. Lubrication System
     • General
     • Maintenance
       • Engine Oil
       • Oil Filter
     • Inspection
       • Engine Oil Pressure
     • Procedures
       • PTO Oil Strainer
       • Suction Pump Oil Strainer
       • Engine Oil Pressure Regulator
       • Oil Pressure Pump
       • Oil Suction Pump
       • Oil Spray Jet
       • Oil Separator Cover
       • TOPS Valve
       • Oil Cooler
• 9. Cooling System
     • General
     • Circuit
     • Technical Specifications
     • Inspection
       • Pressure Cap
       • Hoses and Clamps
       • Cooling System Leak Test
     • Maintenance
       • Coolant Replacement
     • Procedures
       • Clamps
       • Water Pump Housing
       • Water Pump Impeller
       • Thermostat
       • Rotary Seal
• 10. Cylinder Head
      • General
      • Procedures
        • Exhaust Manifold
        • Cylinder Head Cover
        • Spark Plug Tubes
        • Rocker Arms
        • Camshaft Timing Gear
        • Cylinder Head
        • Camshaft
        • Valve Springs
        • Valves
        • Valve Guides
• 11. Cylinder Block
      • General
      • Procedures
        • Timing Chain
        • Chain Tensioner
        • Pistons/Connecting Rods
        • Piston Rings
        • Crankshaft

• The pricing of this manual is determined by the individual seller, and prices may vary between listings. It is recommended to compare prices before making a purchase.
• User comments and ratings at the end of the detail page can assist in making an informed decision about purchasing. After your purchase, consider leaving a review to help other users.
• Don't wait any longer - download the repair manual now and receive a lifetime guarantee for the download, as outlined in our FAQs.
• Contact the seller of the manual using our contact form, and we will ensure your request is forwarded and addressed promptly.

How to Download Your Manual - Delivery Policy